| 624 | 0 | 158 |
| 下载次数 | 被引频次 | 阅读次数 |
分数槽绕组永磁电机因其独特的优点而被广泛应用，其中最显著的优点是空载反电势波形正弦高，这不仅有助于提升电机系统的控制性能，而且能够有效降低电机运行时的转矩脉动和损耗，提升电机品质。首先，对比分析了整数槽绕组和分数槽绕组永磁电机的结构特点和磁路特征。然后，基于绕组函数和气隙磁密函数，推导了永磁电机空载反电势的一般表达式，并从空间谐波角度出发，揭示了分数槽绕组结构改善永磁电机空载反电势波形的内在影响机制。优化设计一台24槽8极整数槽绕组永磁电机和一台27槽8极分数槽绕组永磁电机来验证理论分析结果，对比分析了两台电机的绕组因数谐波与气隙磁密谐波、空载反电势和转矩性能。研究表明，空载反电势第k次谐波由kpr(pr为永磁体极对数)阶次的空载气隙磁密谐波与v=kpr阶次的绕组因数谐波产生，同阶次绕组因数谐波与空载气隙磁密谐波数量越多，空载反电势谐波含量亦越多。最后，研制了27槽8极分数槽绕组永磁电机样机并进行了部分实验，测试了电机的空载反电势波形、相电流和转矩等性能，并与有限元预测结果进行比较，以验证理论分析与有限元预测的正确性。
Abstract：Fractional-slot winding permanent magnet motors(PM) are widely applied due to their unique advantages,with the most notable being their high-quality sinusoidal no-load back electromotive force(EMF) waveform. This characteristic not only enhances the control performance of the motor system but also significantly reduces torque ripple and operational losses, thus improving overall motor quality. Firstly, a comparative analysis of the structural characteristics and magnetic circuit features of integer-slot and fractional-slot winding PM motors was conducted. Next, based on winding functions and air-gap flux density functions, a general expression for the no-load back-EMF of permanent magnet motors was derived. From the perspective of spatial harmonics, the intrinsic impact of the fractional-slot winding structure on optimizing the no-load back EMF waveform of PM motors is elucidated. To validate the theoretical analysis, an optimized design of a 24-slot 8-pole integer-slot winding PM motor and a 27-slot 8-pole fractional-slot winding PM motor is performed. The winding factor harmonics, air-gap flux density harmonics, no-load back EMF,and torque performance of both motors were comparatively analyzed. The findings indicate that the k-th harmonic of the no-load back EMF is generated by the no-load air gap magnetic density harmonic of the order kpr-th(where pris the number of PM pole pairs) and the winding factor harmonic of the order v=kpr. The presence of more harmonics of the same order in the winding factor and air-gap flux density increases the harmonic content in the no-load back EMF. Finally, a prototype of the 27-slot 8-pole fractional-slot winding PM motor was developed and partially tested,measuring the motor′s no-load back-EMF waveform, phase current, and torque performance. These experimental results were compared with finite element predictions to confirm the accuracy of both the theoretical analysis and the finite element simulations.
[1]李烽，王凯，高培伟，等.不同极槽配合交替极永磁电机齿槽转矩和转矩脉动的研究[J].中国电机工程学报，2022, 42(17):6491-6498.LI F, WANG K, GAO P W, et al. Investigation of cogging torque and torque ripple in consequent pole permanent magnet machine with different slot/pole number combinations[J]. Proceedings of the CSEE, 2022, 42(17):6491-6498.(in Chinese)
[2]HE A Q, ZHOU C X, HUANG X Y, et al. Evaluation of fractional slot concentrated winding permanent magnet synchronous machine for electric vehicle application[C]//Proceedings of the 2019 IEEE International Electric Machines&Drives Conference(IEMDC), May 12-15, 2019,San Diego, CA, USA. New York:IEEE Xplore, 2019:988-992.
[3]鞠宇宁，徐忠义，张东宁，等.基于12槽10极永磁电机槽极数及转子磁路结构的研究[J].微特电机，2021,49(5):11-14.JU Y N, XU Z Y, ZHANG D N, et al. Research on the slot-pole combination and rotor magnetic circuit structure based on a 12-slot 10-pole permanent magnet motor[J].Small&Special Electrical Machines, 2021, 49(5):11-14.(in Chinese)
[4]郑军强，赵文祥，吉敬华，等.分数槽集中绕组永磁电机低谐波设计方法综述[J].中国电机工程学报，2020,40（增刊1）:272-280.ZHENG J Q, ZHAO W X, JI J H, et al. Review on design methods of low harmonics of fractional-slot concentrated-windings permanent-magnet machine[J]. Proceedings of the CSEE, 2020, 40(Sup1):272-280.(in Chinese)
[5]柴凤，耿丽娜，裴宇龙.轴裂相整数槽集中绕组永磁容错电机及其匝间短路故障抑制研究[J].中国电机工程学报，2023, 43(13):5203-5217.CHAI F, GENG L N, PEI Y L. Axial split phase integral slot concentrated winding permanent magnet fault toleran motors and its investigation of interturn short circuit faults suppression[J]. Proceedings of the CSEE, 2023, 43(13):5203-5217.(in Chinese)
[6]LIU Y, ZHU Z Q. Influence of gear ratio on the performance of fractional slot concentrated winding permanent magnet machines[J]. IEEE Transactions on Industrial Electronics, 2019, 66(10):7593-7602.
[7]许孝卓，汪旭东，封海潮，等.分数槽集中绕组永磁同步直线电机磁场解析计算[J].电工技术学报，2015, 30(14):122-129.XU X Z, WANG X D, FENG H C, et al. Magnetic field calculation of the permanent magnet syn chronous linear motor with fractional-slot concentrated windings[J]. Transactions of China Electrotechnical Society, 2015, 30(14):122-129.(in Chinese)
[8]康惠林，周理兵，王晋，等.多相分数槽集中绕组表贴式永磁电机谐波电流的确定及其影响[J].电工技术学报，2015, 30(9):22-29.KANG H L, ZHOU L B, WANG J, et al. Harmonic currents determination and their impacts on multiphase fractional-slot concentrated winding surface-mounted permanent magnet machine[J]. Transac tions of China Electrotechnical Society, 2015, 30(9):22-29.(in Chinese)
[9]余洋，张千慧，余宗哲，等.基于反推控制的永磁同步电机稳定性单矢量控制策略[J/OL].(2023-08-04)[2023-09-20].电工技术学报. https：//www.chndoi.org/Resolution/Handler?doi=10.19595/j.cnki.1000-6753.tces.230802.YU Y, ZHANG Q H, YU Z Z, et al. Stability single vector control strategy of permanent magnet synchronous motor based on backstepping control[J/OL].(2023-08-04)[2023-09-20]. Transactions of China Electrotechnical Society.https：/www.chndoi.org/Resolution/Handler?doi=10.19595/j.cnki.1000-6753.tces.230802.
[10]马琛，吉敬华，赵文祥，等.内置式永磁同步电机的极宽调制低振噪设计[J].电气工程学报，2021, 16(4):33-41.MA C, JI J H, ZHAO W X, et al. Pole width modulationbased low vibration and noise design for interior permanent magnet synchronous motor[J]. Journal of Electrical Engineering, 2021, 16(4):33-41.(in Chinese)
[11]韩雪岩，刘文彬，朱龙飞.基于自抗扰的永磁同步电机附加谐波损耗抑制方法[J].电机与控制学报，2024, 28(2):87-98.HAN X Y, LIU W B, ZHU L F. Suppression method of additional harmonic loss of permanent magnet synchronous motor based on active disturbance re jection technology[J].Electric Machines and Control, 2024, 28(2):87-98.
[12]佟文明，吴胜男，安忠良.基于绕组函数法的分数槽集中绕组永磁同步电机电感参数研究[J].电工技术学报，2015, 30(13):150-157.TONG W M, WU S N, AN Z L. Study on the inductance of permanent magnet synchronous machines with fractional slot concentrated winding based on the winding function method[J]. Transactions of China Electrotechnical Society,2015, 30(13):150-157.(in Chinese)
[13]WANG K, GU Z Y, ZHU Z Q, et al. Optimum injected harmonics into magnet shape in multiphase surface-mounted PM machine for maximum output torque[J]. IEEE Transactions on Industrial Electronics, 2017, 64(6):4434-4443.
[14]刘国海，王艳阳，陈前.非对称V型内置式永磁同步电机的多目标优化设计[J].电工技术学报，2018, 33（增刊2）:385-393.LIU G H, WANG Y Y, CHEN Q. Multi-objec tive optimization of an asymmetric V-shaped interior permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2018, 33(Sup2):385-393.(in Chinese)
[15]WANG J B, PATEL V I, WANG W Y. Fractional-slot permanent magnet brushless machines with low space harmonic contents[J]. IEEE Transactions on Magnetics, 2014,50(1):8200209.
[16]陈益广，潘玉玲，贺鑫.永磁同步电机分数槽集中绕组磁动势[J].电工技术学报，2010, 25(10):30-36.CHEN Y G, PAN Y L, HE X. Magnetomotive force in permanent magnet synchronous machine with concentrated fractional-slot winding[J]. Transactions of China Electrotechnical Society, 2010, 25(10):30-36.(in Chinese)
[17]RAZIEE S M, MISIR O, PONICK B. Winding function approach for winding analysis[J]. IEEE Transactions on Magnetics, 2017, 53(10):8203809.
[18]FAIZ J, TABATABAEI I. Extension of winding function theory for nonuniform air gap in electric machinery[J].IEEE Transactions on Magnetics, 2002, 38(6):3654-3657.
[19]CHENG M, HAN P, HUA W. General airgap field modulation theory for electrical machines[J]. IEEE Transactions on Industrial Electronics, 2017, 64(8):6063-6074.
[20]王兴华，励庆孚，王曙鸿.永磁无刷直流电机空载气隙磁场和绕组反电势的解析计算[J].中国电机工程学报，2003, 23(3):126-130.WANG X H, LI Q F, WANG S H. Analytical calculation of no-load air-gap magnetic field and back electromotive force in brushless dc motor[J]. Proceedings of the CSEE,2003, 23(3):126-130.(in Chinese)
[21]杨玉波，王秀和，朱常青.电枢槽口宽度对内置式永磁同步电机齿槽转矩的影响[J].电机与控制学报，2011,15(7):21-25.YANG Y B, WANG X H, ZHU C Q. Effect of slot opening on the cogging torque of permanent magnet synchronous motor[J]. Electric Machines and Control, 2011,15(7):21-25.(in Chinese)
基本信息:
DOI：10.12194/j.ntu.20231012001
中图分类号:TM351
引用信息:
[1]郑军强,徐浩恩,张雨婷等.分数槽绕组永磁电机低空载反电势谐波设计[J].南通大学学报(自然科学版),2024,23(03):66-74.DOI:10.12194/j.ntu.20231012001.
基金信息:
国家自然科学基金青年科学基金项目（52307061）; 江苏省高等学校基础科学研究面上项目（23KJB470033）; 南通大学大学生创新训练计划项目（2023114）