| 310 | 14 | 330 |
| 下载次数 | 被引频次 | 阅读次数 |
离心泵的压力脉动对泵的安全稳定运行有重要影响。为了揭示离心泵运行于不同转速下的压力脉动特性,以一台单叶片离心泵为试验研究对象,测量了泵在不同转速下的外特性曲线,并采用高频压力传感器测量了泵在不同转速时的压力脉动,获得了压力脉动的时域图、频域图,以及不同流量工况下的压力脉动强度分布曲线。外特性试验结果表明:不同转速下泵H-Q曲线基本平行,符合相似换算。试验结果表明:蜗壳内压力脉动从隔舌沿着泵转子旋转方向逐渐减弱,在额定流量工况附近压力脉动强度最小。频域分析表明:压力脉动主频为叶轮转频fn,但由于单叶片离心泵内存在较强的流动分离,在5 fn范围内也存在明显的宽频压力脉动信号。随着转速的降低,蜗壳内压力脉动强度明显降低,但并不完全符合相似换算;转速越高蜗壳-叶轮的势流干涉作用越强,压力脉动周期性越明显;在低转速小流量时尾迹干涉表现明显,压力脉动变得更复杂,周期性减弱。
Abstract：The pressure fluctuations of the centrifugal pumps have a great influence on the safe and stable operation of centrifugal pumps. In order to reveal the pressure fluctuations characteristics of the centrifugal pump at different rotational speed, a single-blade centrifugal pump is used as the test pump and the pump performance is obtained. The high-frequency pressure fluctuations sensor is used to measure the pressure fluctuations of the pump at different rotational speed. The pump performance test results show that the H-Q curves at different rotational speed are basically parallel, which is consistent with similar conversion. The pressure fluctuations test results show that the pressure fluctuations in the volute gradually weaken from the tongue along the direction of the impeller rotation, and the pressure fluctuations intensity is the smallest near the design flow condition. The frequency domain analysis shows that the dominant frequency is the impeller rotational frequency fn, but there is also a significant broadband signal in the range of 5 fn. Pressure fluctuations intensity decreases remarkably with the decrease of the rotational speed, and the pressure fluctuations intensity does not completely match the similar conversion of the rotational speed. The higher the rotational speed, the stronger the potential flow interaction of the volute and impeller, also the stronger the pressure fluctuations periodicity. And the wake interaction is obvious at low flow rate and low rotational speed, thus the pressure fluctuations become more complicated and the periodicity becomes weaker at low flow rate and low rotational speed.
[1]施卫东，张悦，肖宇，等.泵水力设计方法的研究现状[J].南通大学学报（自然科学版），2019, 18(4):1-7.
[2] DRING R P, JOSLYN H D, HARDIN L W, et al. Turbine rotor-stator interaction[J]. Journal of Engineering for Power,1982, 104(4):729-742.
[3] PARRONDO-GAYO J L, G ONZA L EZ-PE R EZ J,FERNA N DEZ-FRANCOS J. The effect of the operating point on the pressure fluctuations at the blade passage frequency in the volute of a centrifugal pump[J]. Journal of Fluids Engineering, 2002, 124(3):784-790.
[4]何秀华.水泵叶频压力脉动形成的机理探讨[J].机械科学与技术，1996, 25(6):38-39.
[5]何秀华.水泵压力脉动的类型研究[J].排灌机械，1996,14(4):47-49.
[6]黄先北，刘竹青.无导叶离心泵蜗壳内低频压力脉动分析[J].机械工程学报，2014, 50(10):170-176.
[7]袁寿其，张玉臻.离心泵分流叶片偏置设计的试验研究[J].农业机械学报，1995, 26(4):79-83.
[8]袁寿其，周建佳，袁建平，等.带小叶片螺旋离心泵压力脉动特性分析[J].农业机械学报，2012, 43(3):83-87.
[9]张伟捷.带分流叶片高速离心泵的压力脉动与试验研究[D].镇江：江苏大学，2012.
[10]张金凤，王文杰，方玉建，等.分流叶片离心泵非定常流动及动力学特性分析[J].振动与冲击，2014, 33(23):37-41.
[11]周汉涛，崔宝玲，方晨，等.不同分流叶片起始直径对离心泵压力脉动的影响[J].浙江理工大学学报，2014,31(3):235-240.
[12]张宁，高波，李忠，等.离心泵口环间隙对压力脉动特性影响的实验研究[J].工程热物理学报，2019, 40(7):1520-1525.
[13]江伟，陈帝伊，王玉川，等.半高导叶对离心泵径向力影响数值模拟研究[J].振动与冲击，2019, 38(10):15-22.
[14]张德胜，王超超，董亚光，等.高比转速斜流泵内部压力脉动特性的实验研究[J].振动与冲击，2019, 38(9):27-34.
[15] CHALGHOUM I, KANFOUDI H, ELAOUD S, et al. Numerical modeling of the flow inside a centrifugal pump:influence of impeller-volute interaction on velocity and pressure fields[J]. Arabian Journal for Science and Engineering, 2016, 41(11):4463-4476.
[16]马鹏飞.转速变化对离心泵性能影响的数值模拟研究及调速调节节能分析[D].兰州：兰州理工大学，2011.
[17]谭林伟.单叶片离心泵非定常流动特性及诱导径向力的数值模拟与实验研究[D].镇江：江苏大学，2018.
[18]姚志峰，王福军，肖若富，等.离心泵压力脉动测试关键问题分析[J].排灌机械工程学报，2010, 28(3):219-223.
[19] G譈LICH J F. Centrifugal pumps[M]. Berlin:Springer, 2008.
[20] PEI J, YUAN S Q, BENRA F K, et al. Numerical prediction of unsteady pressure field within the whole flow passage of a radial single-blade pump[J]. Journal of Fluids Engineering, 2012, 134(10):101103.
基本信息:
DOI：10.12194/j.ntu.20191024003
中图分类号:TH311
引用信息:
[1]谭林伟,牛国平,施卫东,等.不同转速下离心泵压力脉动的试验研究[J],2020(02):56-63.DOI:10.12194/j.ntu.20191024003.
基金信息:
国家自然科学基金项目(51979138);; 江苏省“六大人才高峰”高层次创新人才团队项目(JNHB-CXTD-005);; 江苏省重点研发计划项目-产业前瞻与共性关键技术(BE2016163);; 南通大学人才引进项目(03081237)